How to adjust headlights on Chevrolet Tahoe?

To adjust the headlights on a vehicle, locate the vertical adjustment screws behind each headlight housing and insert an Allen wrench into the top. There are no horizontal adjustment screws. One simple method for adjusting the headlights requires masking tape, a blank wall, and a level floor. Position masking tape vertically on the wall in relation to the vehicle centerline and the centerlines of both headlights. Then, position a horizontal tape line in relation to the centerline of all the headlights. Adjustments should be made with the vehicle parked 25 feet from the wall, sitting level, the gas tank half-full, and no heavy load in the vehicle. Starting with the low beam adjustment, position the high-intensity zone so it is two inches below the horizontal line. Adjustment is made by turning the adjusting screw clockwise to raise the beam and counterclockwise to lower the beam. With the high beams on, the high-intensity zone should be vertically centered with the exact center just below the horizontal line. It is recommended to have the headlights adjusted by a dealer service department or service station at the earliest opportunity.

How to remove the headlight housing on Chevrolet Tahoe?

Start your repair with removing the radiator grille from Chevrolet Avalanche, Suburban, and Tahoe. After loosening the wheel's lug nuts, lift the car with jackstands and take out the front wheel along with the fender well liner's front eye. Pull the electrical attachment of the light housing free simply by pressing on the detent and yanking it off. Only partially loosen the lower outside bolt holding the headlight housing, then fully remove the two upper bolts. When installing, lead the electric motor gently out, making sure the two pins on the housing fit in the front fender bracket holes. Before working on Avalanche, Suburban, and Tahoe models, remove the front wheel and fender well liner. Take the two upper headlight housing bolts out, detach the bumper cover while also removing the lower headlight housing bolt. Hold the headlight cage near its top inside and bottom outside, then push it straight forward to let go of the locating pins attached to the fender panel and radiator bracket. Before taking off, separate the electrical part from the light unit. Undo the installation steps, and align the headlights while you're done.

Genuine Chevrolet Tahoe Headlight

Headlamp

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

66 Headlights found

View related parts
Chevrolet Tahoe Headlight Assembly, (W/ Front Side Marker & Parking & T/Side)
Part Number: 22853025
$159.47 MSRP: $239.50
You Save: $80.03 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, (W/ Front Side Marker & Parking & T/Side); Composite Assembly, Headlamp Assembly
- Position: Front
- Replaces: 15895612, 15882877, 15950807, 20760578
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2014 Chevrolet Tahoe | 4 DOOR 1/2 TON | 8 Cyl 4.8L, 8 Cyl 5.3L, 8 Cyl 5.3L Flex, 8 Cyl 6.0L, 8 Cyl 6.0L Flex
View related parts
Chevrolet Tahoe Headlight Assembly, (W/ Front Side Marker & Parking & T/Side)
Part Number: 22853026
$141.66 MSRP: $212.74
You Save: $71.08 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, (W/ Front Side Marker & Parking & T/Side); Composite Assembly, Headlamp Assembly
- Position: Front
- Replaces: 15882878, 15950808, 20760579, 15895613
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2014 Chevrolet Tahoe | 4 DOOR 1/2 TON | 8 Cyl 4.8L, 8 Cyl 5.3L, 8 Cyl 5.3L Flex, 8 Cyl 6.0L, 8 Cyl 6.0L Flex
View related parts
Chevrolet Tahoe Headlamp Assembly
Part Number: 23490006
$859.64 MSRP: $1295.26
You Save: $435.62 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlamp Asm; Composite Assembly
- Replaces: 22783094, 23387144, 84178176
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2015-2017 Chevrolet Tahoe | 1500 4 DOOR UTILITY | 8 Cyl 5.3L
View related parts
Chevrolet Tahoe Capsule / Headlamp / Fog Lamp Headlamp
Part Number: 15034929
$164.76 MSRP: $247.43
You Save: $82.67 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlamp, Capsule/Headlamp/Fog Lamp
- Replaces: 15602613, 16515827
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2000 Chevrolet Tahoe | CLASSIC 2 DOOR 1/2 TON, CLASSIC 4 DOOR 1/2 TON | 8 Cyl 4.8L, 8 Cyl 5.3L, 8 Cyl 5.7L, 8 Cyl 6.5L Diesel
View related parts
Chevrolet Tahoe Capsule / Headlamp / Fog Lamp Headlamp
Part Number: 15034930
$129.13 MSRP: $185.57
You Save: $56.44 (31%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp, Capsule/Headlamp/Fog Lamp
- Replaces: 15602614, 16515828
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2000 Chevrolet Tahoe | CLASSIC 2 DOOR 1/2 TON, CLASSIC 4 DOOR 1/2 TON | 8 Cyl 4.8L, 8 Cyl 5.3L, 8 Cyl 5.7L, 8 Cyl 6.5L Diesel
View related parts
Chevrolet Tahoe Front Headlight Assembly
Part Number: 84294339
$738.74 MSRP: $1112.87
You Save: $374.13 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, Front; Composite Assembly, Headlamp Assembly
- Position: Front
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2017 Chevrolet Tahoe | 1500 4 DOOR UTILITY | 8 Cyl 5.3L
View related parts
Chevrolet Tahoe Capsule / Headlamp / Fog Lamp Headlamp
Part Number: 16526134
$211.57 MSRP: $317.73
You Save: $106.16 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlamp, Capsule/Headlamp/Fog Lamp
- Replaces: 16524404, 16524850
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2000-2006 Chevrolet Tahoe | 4 DOOR 1/2 TON | 8 Cyl 4.8L, 8 Cyl 5.3L, 8 Cyl 5.3L Flex, 8 Cyl 5.7L
View related parts
Chevrolet Tahoe Capsule / Headlamp / Fog Lamp Headlamp
Part Number: 16526133
$211.57 MSRP: $317.73
You Save: $106.16 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp, Capsule/Headlamp/Fog Lamp; Composite Assembly, Headlamp Assembly
- Replaces: 16524849, 16524403
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2000-2006 Chevrolet Tahoe | 4 DOOR 1/2 TON | 8 Cyl 4.8L, 8 Cyl 5.3L, 8 Cyl 5.3L Flex, 8 Cyl 5.7L
View related parts
Chevrolet Tahoe Headlamp Assembly, Front
Part Number: 84950143
$1188.32 MSRP: $1788.74
You Save: $600.42 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, Frt; Composite Assembly, Headlamp Assembly
- Position: Front
- Replaced by: 85750330
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2022-2024 Chevrolet Tahoe | 4 DOOR 1/2 TON | 6 Cyl 3.0L Diesel, 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe Headlamp Capsule Assembly (Low Beam)
Part Number: 16518159
$80.35 MSRP: $153.94
You Save: $73.59 (48%)
ADD TO CART
Product Specifications
- Other Name: Capsule Asm,Headlamp(Low Beam) ; Capsule, Capsule/Headlamp/Fog Lamp
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-1996 Chevrolet Tahoe | CLASSIC 2 DOOR 1/2 TON | 8 Cyl 5.7L, 8 Cyl 6.5L Diesel
View related parts
Chevrolet Tahoe Capsule / Headlamp / Fog Lamp
Part Number: 16522752
$255.20 MSRP: $484.72
You Save: $229.52 (48%)
ADD TO CART
Product Specifications
- Other Name: Headlamp Asm ; Capsule, Capsule/Headlamp/Fog Lamp
- Replaces: 16517926
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-1996 Chevrolet Tahoe | CLASSIC 2 DOOR 1/2 TON | 8 Cyl 5.7L, 8 Cyl 6.5L Diesel
View related parts
Chevrolet Tahoe Headlamp Assembly, Front
Part Number: 84582597
$1094.16 MSRP: $1646.68
You Save: $552.52 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, Frt; Composite Assembly, Headlamp Assembly
- Position: Front
- Replaces: 84125340, 84294340, 23244326, 22783091, 23420783
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2015-2020 Chevrolet Tahoe | 1500 4 DOOR UTILITY | 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe Headlamp Assembly, Front
Part Number: 84582570
$222.36 MSRP: $330.00
You Save: $107.64 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, Frt; Composite Assembly
- Position: Front
- Replaces: 84294337
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2017-2020 Chevrolet Tahoe | 1500 4 DOOR UTILITY | 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe Headlamp Assembly, Front
Part Number: 84582569
$765.03 MSRP: $1150.16
You Save: $385.13 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, Frt; Composite Assembly
- Position: Front
- Replaces: 84294336
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2017-2020 Chevrolet Tahoe | 1500 4 DOOR UTILITY | 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe Headlamp Kit, Front (Serv) *Service Prim
Part Number: 84582609
$839.09 MSRP: $1264.27
You Save: $425.18 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Composite Assembly
- Position: Front
- Replaces: 84166454
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2018-2020 Chevrolet Tahoe | 1500 4 DOOR UTILITY | 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe HEADLAMP ASM-FRT
Part Number: 85547100
$915.91 MSRP: $1377.78
You Save: $461.87 (34%)
ADD TO CART
Product Specifications
- Other Name: Composite Assembly, Headlamp Assembly
- Replaced by: 85733248
- Replaces: 84861512, 84934279, 85123919, 85004143
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2021-2024 Chevrolet Tahoe | 4 DOOR 1/2 TON | 6 Cyl 3.0L Diesel, 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe Headlamp Assembly, Front
Part Number: 84582598
$1094.16 MSRP: $1646.68
You Save: $552.52 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlamp Assembly, Frt; Composite Assembly, Headlamp Assembly
- Position: Front
- Replaces: 84125341, 23244327, 22783092, 84294341, 23420784
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2015-2020 Chevrolet Tahoe | 1500 4 DOOR UTILITY | 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe HEADLAMP ASM-FRT
Part Number: 86771974
$1117.56 MSRP: $1681.99
You Save: $564.43 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaced by: 85516636
- Replaces: 85001000
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2022-2023 Chevrolet Tahoe | 4 DOOR 1/2 TON | 6 Cyl 3.0L Diesel, 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe HEADLAMP ASM-FRT
Part Number: 85619316
$1187.15 MSRP: $1786.97
You Save: $599.82 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaced by: 85750335
- Replaces: 85152293, 84910947, 84950148
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2022-2024 Chevrolet Tahoe | 4 DOOR 1/2 TON | 6 Cyl 3.0L Diesel, 8 Cyl 5.3L, 8 Cyl 6.2L
View related parts
Chevrolet Tahoe Headlamp Bulb
Part Number: 5972698
Product Specifications
- Other Name: Bulb,Headlamp ; Seal Beam; Capsule, Headlamp, Sealed Beam
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2000 Chevrolet Tahoe | CLASSIC 2 DOOR 1/2 TON, CLASSIC 4 DOOR 1/2 TON | 8 Cyl 4.8L, 8 Cyl 5.3L, 8 Cyl 5.7L, 8 Cyl 6.5L Diesel

| Page 1 of 4 |Next >

1-20 of 66 Results

Chevrolet Tahoe Headlight

The Chevrolet Tahoe Headlight is a part that plays the unique role of providing sufficient lighting on the road in order to minimize instances of having to drive at night. These headlights have been developed over the years to contain the different forms of lighting as inclusive of LED and projector beams which offers a much clearer beam of light as compared to the scattered lights. It is unfortunate that the lenses of these lights are made of plastic and the effects of this material begin to flake off, resulting to minimal light, making it hazardous for drivers. For this vehicle, the Tahoe has endured four generations since its original production in 1995, and the Tahoe has had four unique headlight designs as to properly fit the specific vehicle generation. For this reason, recommended upkeep of the parts and timely substitution of parts are critical in order to avoid the poor performance or enhanced danger when driving.

Each OEM Chevrolet Tahoe Headlight we offer is competitively priced and comes with the assurance of the manufacturer's warranty for the part. Furthermore, we guarantee the speedy delivery of your orders right to your doorstep. Our hassle-free return policy is also in place for your peace of mind.

Chevrolet Tahoe Headlight Parts Questions & Experts Answers

Headlight Assembly, (W/ Front Side Marker & Parking & T/Side)
25897647
Q: How to adjust headlights on Chevrolet Tahoe?
A:
To adjust the headlights on a vehicle, locate the vertical adjustment screws behind each headlight housing and insert an Allen wrench into the top. There are no horizontal adjustment screws. One simple method for adjusting the headlights requires masking tape, a blank wall, and a level floor. Position masking tape vertically on the wall in relation to the vehicle centerline and the centerlines of both headlights. Then, position a horizontal tape line in relation to the centerline of all the headlights. Adjustments should be made with the vehicle parked 25 feet from the wall, sitting level, the gas tank half-full, and no heavy load in the vehicle. Starting with the low beam adjustment, position the high-intensity zone so it is two inches below the horizontal line. Adjustment is made by turning the adjusting screw clockwise to raise the beam and counterclockwise to lower the beam. With the high beams on, the high-intensity zone should be vertically centered with the exact center just below the horizontal line. It is recommended to have the headlights adjusted by a dealer service department or service station at the earliest opportunity.
Headlight Assembly, (W/ Front Side Marker & Parking & T/Side)
22853026
Q: How to remove the headlight housing on Chevrolet Tahoe?
A:
Start your repair with removing the radiator grille from Chevrolet Avalanche, Suburban, and Tahoe. After loosening the wheel's lug nuts, lift the car with jackstands and take out the front wheel along with the fender well liner's front eye. Pull the electrical attachment of the light housing free simply by pressing on the detent and yanking it off. Only partially loosen the lower outside bolt holding the headlight housing, then fully remove the two upper bolts. When installing, lead the electric motor gently out, making sure the two pins on the housing fit in the front fender bracket holes. Before working on Avalanche, Suburban, and Tahoe models, remove the front wheel and fender well liner. Take the two upper headlight housing bolts out, detach the bumper cover while also removing the lower headlight housing bolt. Hold the headlight cage near its top inside and bottom outside, then push it straight forward to let go of the locating pins attached to the fender panel and radiator bracket. Before taking off, separate the electrical part from the light unit. Undo the installation steps, and align the headlights while you're done.